Splitting Axe Cut Wood With a Sharp Felling Axe, Safety and Effectiveness

The first video is a short trailer or propaganda piece to promote the second video.  Below are a few non-technical points I wanted to elaborate on.

I just have a few points I want to emphasize or elaborate on.  I made this video in response to a lot of questions from people about how to deal with wood that is bucked with an axe, since it can't be set on end, or on a block.  Also, because of how I'm operating with one axe, I assumed that it would be a small short axe and that it was intended to retain the edge in chopping condition.  That wasn't so much a plan as it was just how it turned out since that's my world right now.  It is not the only way to approach it.  You could, and most probably do, have a dedicated splitting axe, or maybe a splitting edge on one side of a double bitted axe that can taste a little dirt here and there without much worry, especially if it's ground with a fat bevel that is less likely to suffer severe damage than a thinly ground edge.  A longer heavier axe with a fatter grind is great, as is not having to baby it.  However, using a small, short axe and keeping it sharp requires one to refine technique and strategy, and I think that is a good thing.  I'm also very interested in making whatever tool I have work, and in processing wood with one axe.  You'll hardly find anyone out there recommending an axe ground for felling, limbing and bucking as a splitting axe.  Probably the opposite in fact.

One of the important points in this video is that it requires some investment to figure out what is possible.  Many will discount the possibility of using axes, but not always out of experience, but rather assumption.  I've been guilty of this to an extent myself and it's a mistake.  I personally think that it's worth some investment to figure out what is possible and where an axe is more advantageous than a maul.  I really like splitting with a maul and with some of the stuff I have to split, like dry hardwoods with knots and forks, I'm not likely to ditch my maul altogether.  But, I will keep pushing my limits with axes of various kinds to find out what those limits really are. 

It is not enough to just just smack a few rounds with an axe to see if anything falls off.  It takes some investment in yourself to develop good technique and at least a basic understanding of strategy as presented in these videos.  The flick technique, as Buckin' Billy Ray Smith calls it, or the twist as the Vido's call it, is essential to develop for splitting anything difficult with an axe.  It is just a way to use the power generated in the swing to good mechanical advantage by prying the wood apart on impact instead of just wedging it apart with the shape of the axe.  It can make up for the lower mass of an axe head v.s. a maul in some cases.  I believe that Tom Clark, inventor of the buster axe, an axe optimized for this technique, actually hit the wood with the head tilted at a slight angle.  I think I twist it on impact, but it's hard to know for sure without a slow mo study.  Either way, you'll develop a feel for what works.  It is a skill that has to be learned by some time spent as it's rather clumsy at first to get the timing right. If you have a very sharp short handled axe that you are trying to stay out of the way of, which often requires somewhat awkward positioning, and on top of all that are trying to hit the center of a knotty piece of wood within a quarter inch, you can imagine that some time will have to be put in to gain a reasonable level of skill.  The catch 22 is that it's only by gaining a certain level of proficiency that we can find out what is really possible and not.

The flick technique can be used as an alternative to generating velocity in splitting at times, but should not be thought of as a permanent stand in for it.  The ability to generate a high velocity is a critical tool to have and will only complement that sideways torque when both are needed.  I didn't go much into it, but will in the future.  From my observation and experience so far, high velocity is primarily created by the axe head scribing an arc around a relatively fixed, or at least more fixed, point, like the wrists, elbows, shoulders, waist, or a complex combination of all of those.  it is a complex topic.  With the target at a certain height, it becomes less possible to generate velocity, and the higher you go from there, the harder it gets.  That is one reason I don't use splitting blocks much.  Working close to the ground has the advantage that it is easier to generate velocity, because you have more distance in the swing and can use body mechanics to better advantage.

For me, doing the axe cordwood challenge, in the way I approach it, has been perfect for developing these skills.  I stick pretty much with the axe I'm chopping with, which for now is always small and sharp, and I split in the field with no blocks or contrivances of any kind.  I can only remember abandoning two, maybe three, pieces of wood that were just really knotty or more likely forked.  Even those could likely be split with enough energy, but I know when not to beat my head against a wall for a peanut.  I'm glad that I've invested in this skill, because it will ultimately increase my splitting efficiency in all arenas.  I now have a pretty good idea of what I can get away with and am further refining and defining when an axe will be more advantageous than a maul in splitting sawn rounds as well.  For what it's worth, these videos at least show some possibility that can be put to use or invested in later.  It's not for everyone, and not for every situation, and possibly not for every species, but in the right circumstances it is remarkably efficient and satisfying.  I can say, that just splitting what I incidentally have to cut here, which is Madrone, Bay, Fir, Tan oak and Black oak, that none of those species are consistently difficult to split when young trees are cut and split green.  Older Madrone and Bay can develop some wicked cross grain, but a person is not likely to be cutting those for firewood with an axe, and if they were, large trunks would have to be split, probably with wedges, before bucking, not after. 

The axe and the technique of using it with good strategy are just another set of tools in the bag to be applied where they are best suited, or when necessary.  But, again, it is a tool that has to be developed and refined to be appreciated and applied to anything but the most easily split woods.  I'm glad I've put in some time and forced my progress by using axes that are not ideal for the job and I get to reap the rewards of that from here out.

Did I mention that it's fun?  It's really fun :D

Axe Cordwood Challenge Almost Over and a 1 Week Extension

The axe cordwood challenge is nearly over.  I'm closing in on my own cord and 3 people have already cut a cord or more.  I'm adding a 1 week extension, just because this is the first year and we got started kind of late.  Actually it's mostly because I want people to have time and not rush too much since that is inherently more dangerous.  I still hope to finish mine by June 1st, because it just takes time to dry wood even in our hot summers and June 1st is a good last date to have green firewood cut.  I'm thinking about how to make it more accessible to people in the Southern Hemisphere in the future.  If you finish the challenge, send me info and pics or links to videos by June 7th through the contact on this website.  Also, leaving comments on the official Axe Cordwood Challenge page is a good idea as well.  I think a lot of people would like to know what axes participants used and what you learned whether you finished or not, and the comments section on that page is a good place to leave those.  I'll probably create a page for the 2017 challenge and post all the various links and experiences there.  I've heard from a lot of people who were maybe going to do it and more that have just been using their axes more and practicing and having fun with that.  No one said this completely sucks and I hate it and didn't learn anything, lol.  It's been pretty much good feedback all around and it's been fun having this thing in common with a group of people.

Introducing Axemanship Series, S.T.A.T.E. Five Factors in Effective Axe Work

Somehow in thinking often and long about what makes using an axe effective, I came up with these five things that I think are pretty fundamental.  Surprisingly, they not only formed a real English word to use as an acronym, but three of them!  Some of these are interrelated and it is not a completely tidy concept.  It's more like a framework to define and identify the things we need to work on or have in line to operate effectively.  But if you think about these five factors and removing any one of them, it becomes obvious that effectiveness will suffer.  I think pursuing these ideas will ultimately make us able to function at a high level.  This video series will be 5 videos long aside from this introduction.

Strategy:  Strategy is all important.  Starting to cut a log with no strategy is like starting on a trip with no map, no idea how to get there, just the general direction and that eventually with enough time and fuel you'll probably get there.  Strategy is the planning of the trip to get to center of that log in the most efficient way.  It may not be the shortest direct distance on a bumpy windy road, but it's something that we think will be the fastest or require the least fuel and time.  Strategy is neglected for two reasons.  One is not knowing that it's important.  A lot of beginners will think about getting to the center of the log, but not how to best get there.  Another is lack of faith in the strategy or abandonment of it due to frustration.  Have a strategy, even if you aren't sure it is the best strategy and stick with it.  Sure, vary it, experiment, adapt, but do those things with intent.

Tool:  An axe is not just an axe.  Most of them need work out of the box in order to cut effectively.  There are seemingly infinite axe head designs, handle designs, lengths, weights and grinds that could work effectively.  But, there are certain parameters outside of which chopping will become much less effective.

Accuracy: with an axe is a hard won skill.  It certainly requires time spent, but I believe it can improve more quickly with intent and a little instruction.  Without it, you can't execute your strategy effectively.  Lack of accuracy is not a reason to abandon strategy or give up on attempting to be accurate. Quite the opposite I think.

Technique:  as I mean it, technique is separate from Accuracy and efficiency, though related to both.  What I mean here is the mechanics of chopping and what you do with your body to actually make the axe cut the wood effectively.  If all the other 4 factors are in place, you will still cut the wood, but there are things you can do to make the axe cut better all else being equal.  Mostly we'll be talking about the generation of velocity, but there are other things and not unlikely some I don't know about or haven't noticed.

Efficiency:  Like the word Technique, efficiency could be interpreted in multiple ways.  What I mean here though is economy of energy and motion.  Basically how much result from a given expenditure of energy.  We already know that it can take one person way more energy to get the same log cut in two.  The ideal of efficiency would be to whittle the amount of energy down to a theoretical minimum by letting go of unnecessary, effort/tension/movement/error etc.

As Onix Pyro said in the comments on this introduction video, "practice makes better, not best"  Any ideal of perfect axemanship is a fantasy when knowledge necessarily has limits, the machine is not perfect and the conditions are variable.  And there is no need for perfection or ultimate speed or any other ideal.  But realizing that there is something out there vaguely resembling a theoretical perfection gives us a measure to observe our effectiveness against.  While I lack the teaching experience to prove it, I believe that a little thought and action around these five points will quickly accelerate a beginners effectiveness with an axe and provide a framework for anyone to measure and improve.  I consider this a work in progress and am willing to revise this list if necessary, but it seems pretty solid as far as I can think and from the feedback I've gotten so far.

The Cordwood Challenge, What to Expect and Related Thoughts

A video I shot this morning talking about what to expect when doing the cordwood challenge.  Further thoughts below.

When I did my axe cordwood challenge last year, it wasn’t quite what I expected in every way.  Here are some thoughts on that.  Doing the axe cordwood challenge will affect how the process itself is experienced.  First off, a lot of the experience of anything we do is made up of things like expectation, attitude, pre-conception, social prejudice and just in general what we bring with us that colors our experience.  As a person progresses and improves their skills with an axe, some of those things will change quite a bit.  I tend to think that in most cases, views of the work itself, it’s worth and enjoyability and how much it is percieved as "work" in the negative modern sense, will improve.  On the other hand, maybe that will not be the case if someone has a very romantic and inaccurate view of what it entails to start with.  Who knows.  That is part of this experiment.

Much has to do with efficiency and ability. It is usually a lot more fun and motivating to do something that you are good at and using an axe can be very frustrating if things are not going too well.  Picking up an axe with little or no experience can feel awkward and ineffectual.  In order to be efficient at the work, we have to be able to hit where we are aiming, understand how the axe cuts or doesn’t, have at least a rudimentary understanding of effective strategy, and be able to deliver energy where we want it with a relatively low amount of energy expended; or put otherwise, as little as possible of energy expended is wasted unnecessarily along the way.  It may look easy, but it’s easier said than done and simply takes time with axe in hand to start building physical memory.  Thus, of course, the cordwood challenge in the first place.

The amount of energy expended will go down as coordination is built and excess movement and tension start to fall away.  At least that is how it should happen eventually.  It is possible to waste a lot of energy with excess movement and tension, but the ability to relax into the work will only come with familiarity and comfort with the tool.  I’ll try to offer some tips, but the best recommendation I can probably make is to watch people who are good at chopping and learn that visually.  Watch them a lot and you’ll start to imitate them without even thinking about it.  Look at my recommended axe video play list.  Especially watch competition choppers and the video The Axeman.  Jon Ugalde’s video of 79 year old Basque Axeman Enrique Bildarraz is a great example of high efficiency.  Skills or not, a nearly 80 year old man doesn’t have energy to waste.  Energy efficiency is not synonymous with time or force.

In any case, it takes a lot of time to chop wood with an axe relative to using a chain saw.  That is a given.  Although both speed and force could help you finish work more quickly, It is very important not to force either one too fast.  The forcing of either or both is a great danger, making accidents both more likely and worse when they do happen.  Not only that, but forcing either too much is likely to decrease your efficiency, because errors will be magnified and increased.  Be patient and concentrate on technique, aim and strategy.  The power and speed will happen naturally to a point if they are in your nature.  If they are not, that’s okay too.  You will just proceed somewhat slower.  You don’t actually need a lot of either.  We’ll talk more about the generation of power later.  Beginning choppers should err toward gentle chopping and concentrate on accuracy and system.  Make no mistake.  Power and speed are a waste of energy without accuracy and system.

https://youtu.be/rb9fWu7JES8

Expect to have near accidents as you learn your way around the process and build your catalogue of what can happen.  We go through a higher risk phase when first learning to do something dangerous.  With time (except for the common “cocky phase” somewhere in the middle), dangerous pursuits should become safer as we learn what can go wrong and to foresee potential accidents happening.  We all have a little safety officer in our heads watching out for us throughout every day doing even commonplace things.  Some accidents will be foreseen as a matter of common sense and everyday physics that we are already dealing with regularly our whole lives.  Some accidents are not as easy to see coming.  Hopefully we can shorten that high risk period with some demonstration and discussion, but much has to be learned by experience and real life experience.

I think for men especially, it’s important that we have some kind of at least symbolic destructive activity.  Fighting, hunting and violence in general are in our DNA.  That may be inconvenient at times, but it’s there whether anyone likes it or not.  I find dismembering trees with an axe rather therapeutic and relaxing while being a good outlet for my destructive nature.  The work requires an odd combination of aggression against a living or once living organism, relaxation/effort, and focus while letting go of the chattery overthinking mind.  If you do it a lot, and begin to relax into the work, it will eventually pull you into a good place to be, quite, focused, present, engaged, relaxed and active all at the same time.  I don’t know anything quite like it.

Official Launch of the Cordwood Challenge 2017!, Cut Your Firewood with Axes Only

Warning, some graphic images of axe injuries in this post may be hard to unsee.

Welcome to the cordwood challenge!  The concept of this project is to offer a format in which participants can explore using axes in a way that puts us in a great position to improve our practical axe skills.  If we love the axe, we must love what it has the potential to do, and if we strive to realize some of that potential between ourselves, an axe and pile of wood, is that not the ultimate homage to the axe?

There are more details below, but briefly the challenge is as follows.  Cut 1/4, 1/2, or a full cord, or more using axes only, without cutting yourself or being smashed or crushed by trees and limbs.  Then send a picture or video of you with your firewood and any experiences or insight you’d like to share.  I’m making a leather merit badge and axe strops as incentives, but clearly the real reward is less tangible.

If you plan to take on the cordwood challenge, please read this entire post and watch the video, just to make sure all bases are covered.

First the disclaimer.  I’m providing this challenge as a framework in which axe users can explore improving their axe skills and learn practical application by doing, while having an opportunity to be recognized for your achievement.  What you do with any information I offer, or any information that you gather anywhere else, is your responsibility.  I claim no special knowledge of axes and their use, and don’t claim the information that I offer is accurate or guaranteed to keep you safe in your endeavors.  I accept no responsibility for what you do with any information offered related to this challenge, or on using axes safely and effectively.  If you wind up with an injury doing whatever it is that you choose to do, there will be no one to blame but yourself.  Projecting that responsibility on someone else not only shows a weakness and immaturity of character, but betrays an inherently unsafe attitude toward work and safety.  Using an axe, and felling and working with trees, is inherently unsafe work.  Do not doubt that truth for a minute, and consider this challenge very carefully, and whether it is worth the risk involved to gain these skills.

As I'm preparing this, youtuber Weiderfan, just posted a video about cutting his leg badly with a hatchet.

For your consideration.

View fullsize

View fullsize

Axe wound photos courtesy of http://www.boernebushmasters.org/wilderness-wounds-axe-wounds/

This challenge should not be taken lightly.  Regardless of anything else, it is a considerable time investment in an activity that is somewhat physically demanding (though not as much as you might think) and intrinsically dangerous.  I’ll tell you why I do it, but your motives are your own.  Some people will think you’re cool, but If you think the people around you will be amazed, most of them won't if they even understand what you are doing at all.  So, get ready for quizzical expressions, deer-in-the-headlights looks, head shaking and the need to communicate exactly what it is you are actually doing in graphic detail.  It might be just as well to finish the job after which you can brandish your axe, point at your ricks of drying firewood, and grunt "me make wood!"  That should pretty well do it :)

While there are many possible ways to approach learning to be better axeists, chopping firewood is an activity that keeps it real.  Firewood is a necessity for many of us and puts us in direct relation to our own needs.  What is the difference between making a pile of chips just for practice and making chips that result in a stack of firewood that keeps us warm through the winter?  I don’t know exactly, but there sure is a difference.

Real work = Real Results:  Aside from having practical value firewood processing has some advantages when it comes to learning your way around an axe.  It is real world work.  You will find yourself in all sorts of positions and situations that occur in the field only.  Chopping overhead or chopping the underside of a raised log are challenging and force us out of our comfort zone if we are not used to using an axe in the forest a lot.

More is Better:  There is also the sheer quantity of the work.   You can cut down a tree, limb it and maybe buck it into something you can handle for sawing, but how many trees will you cut down and limb in one year, and how much cutting time is that really going to give you?  The answer is not much.  It was without any doubt, the bucking which most accelerated my skills with an axe last season and forced my attention to accuracy.  Not only does bucking require a lot of chopping, but it is a specific skill all it’s own which requires practice and familiarity to become comfortable with.  Without bucking, you can only get so much practice and only of a certain kind.

Repetition:  And then there is the repetition and timing.  It is very different to go out into the woods at spaced intervals through the year and do just a little chopping, v.s. doing a lot of chopping in a shorter space of time.  If we cut a full cord in a few months, we will reap a reward in skill level from executing that work in closely spaced sessions.

Exercise: I can hardly imagine that the exercise afforded by such clean and engaging physical labor is not a positive thing in the vast majority of cases.  Viewing the effort required as a valuable product of the process rather than a negative factor is not only reasonable in most cases, but I think more accurate.

Who should accept or consider the cordwood challenge?  First some generalities:

Physical Effort:  If you can work efficiently at a moderate pace, chopping firewood may be less work than you might think.  It is just mildly aerobic and doesn’t really requiring a lot strength.  It’s much more about technique and accuracy than force.  I thought I’d be ripped after cutting a cord last spring, but I didn’t notice any particular gains in muscle mass, though I think you could certainly see some if you did enough work in a short enough period of time.  What I did gain though is the ability to process wood with much less effort because I’m more likely to hit where I’m aiming and my strategy has improved considerably.

Access:  Then there is access to wood.  I’m in a good position to process firewood, having acres of overgrown woods in need of management.  For others, the trees may not be there, or there may not be many trees you want to cut down.  Or, maybe you have access to wood, but in an inconvenient location.  Or maybe you have only dead dried up tangly wood that is a nightmare to process.

Conservation: One important thing that might get in the way of taking the challenge is knowledge about trees and forestry.  A certain level of understanding of forest ecology and succession is required to enable us to make intelligent forestry decisions in order to fulfill conservation goals.  If you walk into the woods and can’t tell the difference between one species and another, or generally don’t understand what is going on out there, you probably have no business taking an axe to live trees.  You could stick to dead and dying or diseased trees, or seek guidance, but I hope that no one will just randomly go out and start chopping on whatever tree is handy.  I don’t choose trees just because they will make good firewood.  In some contexts I think that is okay, but most forests have trees that are sick, crowded or can be cut to achieve certain management and conservation goals.  The forest is generally somewhat resilient, but the trees we cut do have a significant effect, sometimes good, sometimes not so much and sometimes simply depending on what our goals are.

Danger Danger:  There is much to consider when taking on this challenge.  It is not to be taken lightly.  The danger alone should be carefully considered.  Perfectly capable axemen can end up with serious injuries.  The perspective that the whole idea is just dumb for that reason alone has some merit.  But, there are always different ways to look at anything.  If you want to be good at using an axe, then this is a great way to get there.  It may be the best way, aside from operating in a similar context with a skilled teacher.  And doing dangerous things is not without it’s rewards.  Danger should sharpen our focus and foster a clarity and contrast that cruising through safe tasks all day dulls.  There is, or should be, an immediacy and presence of mind that comes with activities, requiring focused engagement to safeguard our well being.  I think for men especially swinging a dangerous tool/weapon around to dismantle trees satisfies something that we are supposed to experience.  Someone did a study on the effects of various activities on testosterone levels, and cutting wood with an axe raised testosterone levels the most out of all activities!  Hitting trees with sticks would surely not yield the same result.

for simplicity’s sake, I’m dividing us into categories in reference to who should take the challenge

Beginners:  I’m inclined to discourage beginners from taking on this project, even at the lowest level of 1/4 cord.  I don’t think it’s impossible depending on the person, but learning to use an axe takes time.  It is always dangerous, but in the beginning it is extra dangerous.  Having a goal or deadline isn’t probably the best attitude to take when learning a new dangerous skill.  If you start testing the waters this year and end up with a stack of wood, you’re in, but don’t commit to something that you don’t understand enough to know what you are getting into.

Mid level, some experience:  I think this is the group that can benefit the most immediately and jump right into the project.  I consider myself in this category, though higher up in it than I was last spring after cutting only a cord of wood.  Anyone that writes or makes video content about axes and using axes I would especially like to encourage, to do the cordwood challenge.  It will build your credibility and legitimacy in both your eyes and others and can only benefit your audience and content quality.

Veteran choppers:  I’d also like to see some veteran choppers get involved.  If you cut your firewood with an axe already, that’s fine, do the challenge anyway and show the rest of us how it’s done.

A note to women.  Women can definitely use axes effectively.  You don’t have to be a lumberjack dude to use an axe.  A large stronger man of the same skill level is going to outchop you, but your typically lighter structure and stature does not preclude your participation or ability to chop effectively.  Not only are accuracy, efficiency and technique much more important than strength and aggression, I can attest personally that the instinct to try to force an axe through a log by strength is very ineffective and often the very thing that will wreck my accuracy and good form.  I still battle with that problem frequently.  This is a total boys club for sure, but we’d love to have you on board, possibly more than you’d like actually ;)  I’ll try to make you feel as comfortable as possible here and delete or check any disrespectful comments.

View fullsize

Images from AxeConnected.blogspot.com

Kids and Young Adults: If you are under 18 I need to talk to your parents if you’re going to submit to the challenge.  18 is the legal age of adulthood in my country and I don’t want anyone’s parents thinking I’m responsible for encouraging their offspring to undertake a dangerous activity.  Before you leave comments, submit pictures, etc., have them contact me through the contact tab on this website.

No Pressure:  In conclusion, consider taking on such a challenge thoughtfully.  I don’t want to discourage people in general, obviously I think it’s overall a good idea for a certain type of person at a certain level of skill, and believe there are many potential rewards.  For people at any level that are on the fence, planning to spend a year warming up and getting gear together in a feeling out process is probably a great way to go.  After all, you may not know if you like the work or not.  Fixing up an old axe or tuning up a new one, learning to sharpen, and w chopping are a lot to take on for a first season.  If you end up with a quarter cord or more this year, you are welcome to submit your entry.  I just don’t want anyone making commitments they can’t keep.  You can simply let me know that you are thinking about doing the challenge, or just tell me when you are part way through, or even when you’re finished.  I’m good with whatever as long as you aren’t getting yourself into something that you will regret, or that will put you under an unsafe degree pressure.  Whatever the case, you can leave comments to that effect on this page.

Rules

Saws:  I’m making one single exception for saws, which is making the back cut when needed for safety reasons.  You can’t really wedge a back cut made with an axe, so making a back cut with a saw opens new possibilities for wedging trees in the direction you want them to go, which may be needed for safety or to prevent hang ups or damage to other trees.  Most of the time you won’t need to and you’ll get little enough experience making felling cuts as it is, so don’t use this out if you don’t need it.  I have never used it.  On the other hand, certainly DO use it if it seems necessary for your safety or might prevent the damage or death of important adjoining trees!  Otherwise, NO SAWS, that’s the whole point. 

Mauls and Splitting:  You may use splitting mauls for splitting the wood, but I would very strongly encourage you to use whatever axe you fell and buck with as much as possible.  You might be surprised what you can pull off with good aim, technique and strategy.  I do all of my splitting with whatever axe I’m using for the other processes involved.  If I can’t split it but it fits in the stove, I leave it as an “overnighter” log, which I actually have a shortage of this year.  If it needs to be split and the axe is not enough, I chop out a couple of rough wooden wedges on the spot and use those.  Tim of Oxbow Farms was skeptical that he could split the wood with an axe, but encouraged him to keep at it and after trying the golf swing method for a while, he’s a convert.  You can do whatever you want, but you will learn a lot if you really stick with your axe and concentrate on your aim and technique.

Achievement levels:  The levels are 1/4 cord, 1/2 cord, or 1 full cord, or more.  1/4 cord gets recognition and your picture or video featured in a video and web page.  1/2 cord and up gets a merit badge that I make from leather which I tan here on the homestead.  It’s sort of like the boyscout merit badge for accomplishing something, but way cooler!  I’m still working out the details on that, but the prototype looks pretty cool.  1 cord gets the badge plus a pocket axe strop.  You can watch the making of the strops in my video series following that entire process.  They are made entirely from scratch from materials gathered here.  Clearly for anyone surpassing a cord that is a reward in itself,

Deadline is June 1st 2017:  If you live in the southern hemisphere, contact me and will figure something out.  I honestly haven't given much thought to how to deal with that problem.  Suggestions welcomed. 

Send me pictures of you with your finished stacks of wood or post a video and write as much as you want about the experience or not.  I’d love to hear about your experience and I’m sure others considering the challenge in the future would as well.  Be sure to include the axe or axes you used.  If you make a video and don’t have a way to post it, we can work out a way to get the footage to me so I can edit it into another video or post it on my channel.

Tim @ oxbow farms youtube channel has already finished a full cord and is thinking about doing a second cord because he’s having so much fun and learning so much.  Watch his cordwood challenge playlist.

 hub I have an official page that is the Hub for the project.  Please leave all relevant declarations related to the cordwood challenge there rather than on any of my youtube videos.

Resources: I can only offer so much support on technical advice like felling and gear, due to limitations of time and energy as well as qualification in many cases.  Please avail yourself of whatever information is out there on axes, chopping, felling trees, forestry, etc., but be critical.  A list of resources appears below.  Even though I feel I’m not the best person to do it, I’ll be making some videos on axe use and safety in support of the project.  Hopefully some of those will be out sooner than later.  I can’t completely endorse anything as entirely accurate, “correct” and relevant, these seem to be some good sources of information.  I would recommend consuming all of them.

Books:

Mors Kochanski,  Bushcraft  Excellent book all around and great axe use and safety stuff.  A must read.  

Dudley Cook, The Axe Book  And outstanding work focused on using axes for firewood processing.  Another must read.

Peter McClaren’s Axe Manual Read free online.  Somehow I just discovered this book, so I haven’t even read it yet, but it looks potentially amazing.

Bernard S. Mason Woodsmanship  A great old book with considerable detailed axe information.  Download it here for free

Woodcraft and Camping, E. H. Kreps   Download free:

An Axe to Grind  Government manual on axe use, maintenance and safety download free

Video: 

Best Axe Use and Safety Videos Playlist  Some great stuff in here all around and a few exemplary examples of axemanship! 

Cordwood Challenge Playlist.  Any supportive videos I make on axe use and safety will go in here.

Websites, Forums Etc:  There are no forums of discussion type groups I know of that are solely or primarily focused on working axes.  If you know of one, please let me know.

AxeConnected  The Vido's axe website.  Infrequently updated, but deep insightful content from long time axe users.

Facebook's Axe Junkies  Over 20,000 members strong.  Axe Junkiest seems to be the hub of internet axe culture Lots of advice available on restoring, handles, sharpening and such,  and there are a lot of knowledgeable members that will sometimes comment on practical questions.

Reddit's AxeCraft  Not a lot on practical application, but again some experienced knowledgeable members.  I've had some good conversations there.

Have fun and try to stay safe!

First Entry for the Cordwood Challenge, Tim Springston of Oxbow Farms

Even though I haven't really officially kicked off the cordwood challenge (working on it now) Tim Springston (on youtube as oxbow farm) has already finished a cord of wood!  Way to go Tim!  He says it was so much fun and he has learned so much that he's thinking of chopping another cord this year.    Tim has been making some videos talking about the project.  I'm embedding his cordwood challenge playlist here.  Congratulations for finishing the challenge in style, being the first ever to finish it, and finishing it safely.  When I get the strops and cordwood challenge merit badges together they're in the mail to Tims neck of the woods.

Bucking Without Sucking, Toward Efficient Notching With an Axe

View fullsize

I have a great video coming out on tanning the deer skin for the axe strops I'm making for the cordwood challenge.  But the file is huge and my internet was acting up so I made this short video out of something I had sitting around from another project so I could keep my every Saturday posting schedule.

In the video clip, I'm just messing about and demonstrating on this log.  I wasn't actually processing this fallen Black Oak tree, it was just a good size and condition for the project which will be a more in depth video and blog post on common mistakes in bucking, as well as the psychology that leads us into those mistakes and keeps us there.  Bucking well is a hard won skill and can be very clumsy, especially under varied field conditions when working at ground level.  There are several important take home messages in this video that can help people get passed common pitfalls. 

If you see something like the video I'm adding below by Ben at Ben's backwoods on throwing big chips, it looks exceptional in the backdrop of the average axe bucking video (excluding competition choppers), but it shouldn't seem so exceptional.  This is the kind of accuracy, strategy and adherence to a proven system that can make chopping, fun and much more efficient than most people imagine it could be.  I'm also linkng a Basque axe race that viewer Jon Ugalde posted in the comments on todays video that is truly epic!  Those are beech logs they're cutting.  Seriously awesome.